A strong technological nation starts with repairing mobile phones

Chapter 84 Large glass panel, new track!
Just talk about the cost. A piece of glass panel, from raw materials to finished products, goes through dozens of processes, and the front forming and back coating processes are both fine.

Based on the current product parameters of Corning and Born, glass of such a large size will be scrapped if one is not careful during the cutting and polishing process. The yield rate after all the processes will be terribly low, and the total cost is simply unacceptable.

But these are not problems for Tiansheng Optics. The first technology Chen Jinghong used has solved the brittleness problem. The size is now stuck at 100 inches only because of the current equipment problems. If you want to break through this sub-size, you only need to upgrade the equipment once.

By this calculation, Tiansheng Optics is really just as Li Dongsheng said, Tiansheng Optics is really invincible in this track.

After figuring out the key, Chen Jinghong said to the two of them without hesitation: "Director Nan is right, Tiansheng Optics and Huaxing Optoelectronics can indeed cooperate in many areas.

We at Tiansheng Optics can’t say otherwise, but our large-size technology has been ahead of our peers for more than a decade, and our cost control is much better than theirs.”

Li Dongsheng originally only spoke according to his own inner thoughts. Now Chen Jinghong personally admitted that large-size glass panels can be produced, and most importantly, the cost can be controlled.

His attitude changed immediately, his face became serious, and he asked in a very serious tone: "Mr. Chen, are you sure that your company can really produce large-size glass panels at a low cost?

You have to know that the large size I am referring to is about 80 inches, and even if the size requirement is met, we still have very high requirements for the strength, toughness and light transmittance of this piece of glass. "

Li Dongsheng emphasized the latter part of his words deliberately, fearing that Chen Jinghong was fooling him.

"Of course!" Seeing Li Dongsheng getting serious, Chen Jinghong immediately put away his smile and said seriously: "If Mr. Li does not believe in the strength of Tiansheng Optics, can we make a batch of samples for you to see?

In order to avoid you thinking that we can't meet the mass production requirements, how about you tell me the size and proportion now and I will ask the production department to produce it. How about we produce 100 samples for you within an hour?"

"One hundred?" Li Dongsheng wondered if he had heard it wrong.

"Great! One hundred pictures an hour. You can provide three sizes and ratios, but we have requirements for the ratio. If the ratio exceeds 16:9, we can only produce a maximum of about 80 inches." Chen Jinghong said without any pressure.

Currently, he is in charge of almost all the equipment on the production line, so he naturally knows what he can produce.

As long as there are no special-shaped holes that need to be drilled, producing these glass panels is just a matter of changing the parameters, which is not difficult at all.

Seeing that Chen Jinghong was indeed not joking, Li Dongsheng was also wondering whether Tiansheng Optics was really as powerful as he said, and could produce the sizes he required within an hour. He immediately quoted three sizes.

The ratio is based on the general TV 16:9, but the size requirements are 60, 75, and 98 inches respectively.

Chen Jinghong did not hesitate and immediately informed Li Hanwu of Li Dongsheng's request and asked him to arrange for the birth to start immediately.

"Mr. Chen, don't we need to make the mold first and do the final manual polishing process?" After seeing Chen Jinghong finish his instructions, Li Dongsheng asked in confusion.

Normally, if you want to produce a glass panel, the first step is to make a mold according to the specifications, and then it has to be manually polished and trimmed before it can enter the coating process, coating inspection and factory delivery.

But at this moment, Chen Jinghong gave the order and guaranteed that more than one hundred pieces could be completed in an hour. This amount of time was probably not enough for opening the mold, let alone for the workers to polish it. After all, this was something beyond their plan, and they couldn't arrange all the workers to do the polishing.

"According to our plan, there is no need to make a special mold for parts larger than 30 inches. Although making a mold can increase production capacity, if the size is too high, we will choose to reduce the speed and use laser cutting, so that the size and accuracy can be better guaranteed.

As for polishing, I believe that even without this process, this batch of glass panels will satisfy you, Mr. Li."

"Then I'll wait and see how Mr. Chen is going to satisfy me."

After Li Dongsheng finished speaking, the three people present immediately burst into laughter.

Among them, Nan Wenyu's thoughts were constantly turning at this moment. Originally, the district had already had a high opinion of Tiansheng Optics and believed that Tiansheng Optics had great potential.

Otherwise, he wouldn't have been so eager to find a way to help as soon as he saw that Tiansheng Optics had some problems, and he wouldn't have asked Huaxing for help before Chen Jinghong even asked.

But now, Nan Wenyu heard that Tiansheng Optics could actually produce the world's difficult problem, large-size glass panels, and most importantly, control the cost within an acceptable range. He knew that they still did not pay enough attention to Tiansheng Optics.

An hour passed quickly, and Li Hanwu did not disappoint Chen Jinghong. He had completed what Chen Jinghong had asked him to do a few minutes ago.

Seeing Li Dongsheng who was already impatient, Chen Jinghong received Li Hanwu's report and immediately took Li Dongsheng and Nan Wenyu to the warehouse without any nonsense.

When the three arrived at the warehouse, Zhou Pingshen and Li Hanwu were already waiting for them there.

"Mr. Chen!" The moment he saw Chen Jinghong, Zhou Pingshen trotted over and said with a smile.

Although Chen Jinghong did not inform him, he still chose to come and take a look after he knew about this.

"This is Li Dongsheng, the president of Huaxing Optoelectronics!" Chen Jinghong said, turning to look at Li Dongsheng and introducing him, "Boss Li, this is Zhou Pingshen, the general manager of Tiansheng Optics who is in charge of the optical glass business. If we want to cooperate in the future, you can ask your subordinates to contact him!"

When Zhou Pingshen heard that the person in front of him was Li Dongsheng, the president of Huaxing Optoelectronics, his eyes lit up immediately. He excitedly reached out and shook Li Dongsheng's hand and said, "Mr. Li, it's my honor to meet you."

"Hey~ hello!" Li Dongsheng said with an embarrassed look.

Everyone has seen Nan Wenyu, so there is no need to introduce him. Zhou Pingshen is also very experienced and did not ignore Nan Wenyu while greeting Li Dongsheng.

"Mr. Li, these should be produced according to the size you just requested!"

Everyone came in front of Li Hanwu and looked at the pieces of glass wrapped in bubble paper placed on the wooden rack on the ground. Chen Jinghong turned to Li Dongsheng and said.

This time, Li Dongsheng did not respond to Chen Jinghong's words.

He walked directly to the glass, pulled out a glass panel and carefully tore off the protective foam paper.

As expected, there is indeed a transparent glass panel inside, which at a glance should be around 75 inches.

Li Dongsheng first touched the edge with his hand to estimate the thickness of the glass. According to the requirements, the thickness of these glass panels cannot exceed 1.5 mm.

After a rough touch, Li Dongsheng knew that it should be no more than 1.5 millimeters.

The thickness met the standard, so he began to roughly test the flexibility. This test was very simple. He held one side with both hands and then shook it quickly. According to previous experience, with such a large glass panel and such a thin thickness, a slight shake would shatter the entire piece of glass.

"Swish, swish, swish!" Soon the glass made a crisp sound, which was a bit like the sound of iron sheet shaking.

And as he shook it, the glass panel swayed like the waves.

At first, Li Dongsheng only dared to use a small amplitude. Later, when he saw that the glass panel was fine, he gradually increased the amplitude. Until finally, Li Dongsheng used almost all his strength but still couldn't make the glass panel break.

Until he ran out of strength, the other side of the glass was stuck on the wooden frame, and he exerted more strength, and the whole piece of glass suddenly folded in half. The originally indestructible glass panel shattered with a "crack", and then it remained intact, but the whole piece of glass was now covered with cracks.

"Our product is not foldable. It must have been folded at an angle of more than 80 degrees, and the force was applied instantly, so it broke!"

If we were to say who was the most nervous at the scene at the moment, it would definitely be Li Hanwu, who was in charge of production. After all, as long as there was a problem, he would have to take the blame. Seeing this situation, his face turned pale and he immediately began to explain, for fear that Chen Jinghong and Li Dongsheng hadn't seen the scene of the shattering just now.

"I know, the other side must have been stuck by the wooden board!"

Li Dongsheng first put down the broken glass in his hand, then nodded and said.

As the person involved, he naturally knew best what had just happened. Now was not the time to lower the price, so there was naturally no need for him to tell lies.

Of course, at this moment he had already been impressed by the performance of the glass panel. He was thinking about how to maximize the role of these panels and had no time to think about anything else.

"Mr. Li, how is it? Did our product not disappoint you?"

"It's really good. If the TV can be equipped with this glass panel, the lifespan should be greatly extended, and the display screen will not be shattered directly by the slightest external force!"

All the ultra-broad LCD TVs on the market now, without exception, cannot ignore this fatal flaw. Since they are not equipped with glass panels and only have a thin layer of protective film, the display screen will directly shatter as long as it is subjected to the slightest external force.

This situation is very common. There are a lot of such videos on the Internet. Some of them are about children accidentally hitting the TV with objects, and the TV that was originally in good condition is directly broken into pieces. People who are playing accidentally hit the TV with objects in their hands and the TV breaks into pieces.

And since the most expensive part of a TV nowadays is the LCD screen, this crack almost means that the TV is scrapped and is not worth repairing at all.

However, if these TVs are equipped with glass panels, the excellent strength and toughness of the glass panels will allow them to quickly absorb and disperse the force, and the TVs will soon be able to get rid of the title of fragile items.

Li Dongsheng left. He came with the mentality of saving Tiansheng Optics, but when he left, he took away the batch of glass samples that Chen Jinghong asked Li Hanwu to produce.

He walked very quickly, almost as if he couldn't wait.

Of course before leaving, Nan Wenyu and he both assured that the matter of the Rice Group would be resolved quickly, so Chen Jinghong didn't have to worry about it.

……

Xiaomeisha, a famous scenic spot in Pengcheng.

"It's been a while since we as a family have come out to play!"

During the rare vacation, Xu Qing followed Chen Jinghong's advice and handed over most of the company's affairs to her subordinates.

Chen Jinghong and Xu Qing hit it off immediately and decided to come to Xiaomeisha for a family visit today.

At this time, Xu Qing put one hand on Chen Jinghong's shoulder, and looked at her brother teasing Chen Yuanyuan in front of her with a smile, and her happiness was revealed in her words.

"As long as you want, I will accompany you out for a walk every week!" Chen Jinghong put his arm around Xu Qing's waist and promised with a smile.

"Baba, Mommy, please hurry up, I want to see dolphins!"

Just as the two were talking sweetly to each other, Chen Yuanyuan ran over from Xu Weirong's side and shouted at them with an impatient look on her face.

After saying that, he didn't care about the two people's current posture, and squeezed in between them and forcibly separated them. He held the hands of the two people in each hand and ran forward.

"Haha! Okay, let's go faster!"

Chen Jinghong knew that Chen Yuanyuan was so anxious because she was about to see dolphins for the first time and could not wait any longer. He first smiled at Xu Qing and then lowered his head and said to Chen Yuanyuan.

As the performance was about to start, the aquarium was already packed with spectators. Chen Jinghong and his companions quickly took their seats and waited for the performance to begin.

After so many years in Pengcheng, this is the first time that Chen Jinghong and Xu Qing's family have come to Xiaomeisha for a visit. In the past, they were deterred by the hundreds of yuan ticket price for Xiaomeisha and every time they came, they would only go to Dameisha, which does not charge admission, to see the sea and yachts.

"Wow! Baba, look, it's a dolphin, a living dolphin!"

"Wow, this whale is so big, it can eat Yuanyuan in one bite!"

Wow... Under the instructions of the keeper, the whale splashed large waves and hit the people in the audience.

It was no surprise that Chen Yuanyuan was soaked by the waves.

"Bad guy, the whale is so bad! Yuanyuan doesn't like it!"

A wave came and wet Chen Yuanyuan's head directly. Chen Yuanyuan quickly stretched out her little hand and wiped her face twice, saying in a very aggrieved tone.

That expression is exactly the same as when you are angry with your friends and say that you don’t want to play with me anymore.

"Ha ha……"

Chen Jinghong, Xu Qing and Xu Weirong were all amused by Chen Yuanyuan's performance.

The child got angry quickly and calmed down quickly. When the whale continued to perform, the kid performed the action of a whale diving into the sea.

Chen Yuanyuan opened her mouth wide again and said exaggeratedly, "Whales are so amazing, Mommy, Yuanyuan wants to raise a whale!"

"Take care of your head! Aren't you afraid that it will eat you in one bite?" Chen Yuanyuan reached out and pinched Chen Yuanyuan's little face, pretending to be very serious.

"Yes!" Chen Yuanyuan was really shocked when she heard it, and quickly shook her head and said, "Yuanyuan is not allowed to be raised anymore. Mommy, dolphins are cute, but their mouths are small and they can't eat Yuanyuan. Yuanyuan, let's raise the dolphin!"

Xu Qing was speechless after hearing this, and then pointed at Chen Jinghong and said, "Talk to your dad and ask him to help you catch one in the sea for you to raise!"

Chen Yuanyuan's attention was indeed shifted to Chen Jinghong. She immediately opened her eyes wide and looked at Chen Jinghong with anticipation.

Now it was finally Chen Jinghong's turn to have a headache...

　Thanks to: jackworfskin, this chapter is for the boss! Currently the first order is 1400, everyone please help him break through 1500!
　
(End of this chapter)